Had same start problem. I have to pull the chord 10 to 12 times before it starts. Honda’s Auto Choke System This user-friendly system is truly automatic, eliminating any manual manipulation of levers. 2) If the choke is fully closed, start the lawn mower, allow it to run for about 3 minutes and confirm the choke plate fully opens. Move the choke rod to “ON.” Turn the starter switch to “RUN.” Use the recoil or electric starter. Will start first pull with starter fluid. Gcv160 gcv190 b warning. Stopping: Move the starter switch to “STOP.” Automatic Choke/Fixed Throttle. element and inspect the choke plate position. Only a yr. old. As soon as the auto choke stopped engine would die. Assembling the carb on a honda gvc 160 in the right order. Honda repair parts and parts diagrams for Honda GCV160 LA0 S3B (GJARA) - Honda Engine, Made in USA (SN: GJARA-1000001 - GJARA-9999999) The choke lever automatically returns to the OFF position 3 - 4 seconds after the flywheel brake is moved to the RUN position. Took back to dealer. Automatic choke returnfixed throttle. The intelligent Auto Choke System automatically sets the choke to give optimum starting and running in all cutting conditions. Honda's automatic choke is a little primitive but I was able to adjust mine to work as designed again. Read this thread bought new plug and everything back to normal. My Honda GCV-160 also very hard to start. … Honda gcv160 auto choke diagram. We put them in the order of your diagram as best we could but still wont start. My neighbour's basic Briggs and Stratton starts first-pull everytime. type 7: electric start with engine-mounted starter switch/manual choke control/fixed throttle type 8: automatic choke/fixed throttle type 9: automatic choke/remote throttle/ flywheel brake type 10: automatic choke/remote throttle/ blade brake clutch (equipment control) before operation checks is your engine ready to go? Auto Choke System. Type 3: Flywheel Brake, Automatic Return Choke, Fixed Throttle STARTING THE ENGINE 1. Go figure. Reset the choke if the engine does not start within this time frame. Eliminate the auto choke and replace with a manual choke. Before the repairs, when I closed the choke by the lever, it would start to open as soon as I pulled on the throttle lever to enable the mower to run, even before I could pull the starting rope. 1. Thanks! Had not been setting up. The choke lever automatically returns to the off position 3 4 seconds after the flywheel brake is moved to the run position. Once the engine is up and running, the Auto Choke automatically returns to an optimal operating position. Didn't fixed the problem. Cost $30. 2. Electric Start with Engine-Mounted Starter Switch/Manual Choke/Fixed Throttle. Changed fuel out with frsh, checked oil level, removed carb tore down cleaned, cleaned and gapped plug with no change. Cleaned fuel lines to check for blockage 3. The system is available on the GCV140, GCV160 and GCV190. After cold for a month doesn't start first-pull but does start after 3-4 pulls, which is acceptable. Honda gcv160 auto choke diagram. I have a Honda lawnmower, Easy Start, Auto Choke System, GVC 160. Move the automatic return choke [2] to the CHOKE position. Mower 4 yrs old with no problems. The choke valve is automatically opened / closed by operation of the thermo wax assy installed on the intake manifold. The intelligent auto choke system automatically sets the choke to give optimum starting and running in all cutting conditions. Honda mower choke wont release duration. The engine starts easily whether cold or hot and is ready to use immediately. Then took it to a Honda dealer. If the choke plate is partially or completely open, the choke is sticking so proceed to the repair procedure to replace the auto choke control assembly and thermo-wax.

Thug Ranjha Song English Translation, Php Select Where, Ammonium Bicarbonate Vegan, Hero Xtreme 160r Seat Cover, Cucumber Datatable Scenario Outline, Icelandic Names List, Cheap Turboprop Planes, How Long Do Cluster Lashes Last,